Slant_fin V-33 Manuel d'utilisateur télécharger pdf

HOT WATER MODELS V-33 THROUGH V-180

INSTALLATION AND OPERATING INSTRUCTIONS

GAS-FIRED CAST-IRON BOILERS FOR NATURAL AND L.P. PROPANE GASES

CONTENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .PAGE

Ratings and Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . .2

Installation Requirements:

Boiler Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3

Boiler Foundation . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3

Minimum Clearance . . . . . . . . . . . . . . . . . . . . . . . . . . . .3

Venting Requirements . . . . . . . . . . . . . . . . . . . . . . . . . .3

Chimney and Type “B” Venting . . . . . . . . . . . . . . . . . . .4

Horizontal Venting . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

Vertical Venting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

Regular Inspection . . . . . . . . . . . . . . . . . . . . . . . . . .6

Gas Piping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

Electrical Controls and Wiring . . . . . . . . . . . . . . . . .11

Boiler Room Air Supply and Ventilation . . . . . . . . . . . .11

Water Piping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11

Operating Instructions:

Filling and Venting Water Systems . . . . . . . . . . . . . . . .12

Initial Start, Safety and Lighting Instructions . . . . . . . .12

IID System with Honeywell VR8204 or VR8304 . . .12

Bur

ner Adjustment, Checking Gas Input . . . . . . . . . . .13

Care and Maintenance:

General Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . .14

Water Level Check . . . . . . . . . . . . . . . . . . . . . . . . . . . .14

Annual Inspection and Cleaning . . . . . . . . . . . . . . .14

Safety Check for Control Systems . . . . . . . . . . . . . . . .15

Protection from Freezing . . . . . . . . . . . . . . . . . . . . .15

ater Treatment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15

Appendix A and B . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16

Sequence of Oper

ations . . . . . . . . . . . . . . . . . . . . . . . . . .

Wiring Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17

Pump or Valve Zoning of Water Boilers . . . . . . . . . . . . . .18

General T

roub

leshooting Guide

. . . . . . . . . . . . . . . . . . . . .

Piping a Heating-Cooling System . . . . . . . . . . . . . . . . . . .20

Replacement Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20

IMPORTANT

READ ALL OF THE FOLLOWING

WARNINGS AND STATEMENTS

BEFORE READING THE

INST

ALLATION INSTRUCTIONS

WARNING

LIQUEFIED PETROLEUM (L.P.)

PROPANE FIRED GAS BOILERS

Installation location ONLY as permitted in paragraph

entitled "LIQUEFIED PETROLEUM (L.P.) PROPANE

GAS FIRED BOILER LOCATION" on page 3 of this

instruction book.

The above warning does not apply to

NATURAL gas

fired boilers.

The installation must conform to the requirements of

the authority having jurisdiction or, in the absence of

such requirements, to the National Fuel Gas Code,

ANSI Z223.1-latest edition. The installation must also

conform to the additional requirements in this Slant/Fin

Instruction Book.

In addition where required by the authority having juris-

diction, the installation m

ust conform to American Soci-

ety of Mechanical Engineers Safety Code f

Controls and Safety De

vices f

or Automatically Fired

Boilers

No. CSD-1.

ARNING

This boiler

, gas piping and accessor

ies must be

installed, connected, ser

viced and repaired by a

trained, experienced service technician, familiar with all

precautions required f

or gas fired equipment and

licensed or otherwise qualified, in compliance with the

author

ity having jurisdiction.

This man

ual must be left with owner and should be

hung on or adjacent to the boiler f

or reference

Printed in U.S.A. 301 Publication No.V-40

art No. 44-0596 Rev. M

Victory

™

1 2 3 4 5 6 ... 19 20

Résumé du contenu

Page 1 - IMPORTANT

HOT WATER MODELS V-33 THROUGH V-180INSTALLATION AND OPERATING INSTRUCTIONSGAS-FIRED CAST-IRON BOILERS FOR NATURAL AND L.P. PROPANE GASESCONTENTS . .

Page 2

10VICTORYFigure 9. Vertical Venting (3 IN.): All Victory ModelsAll items shown below are REQUIRED. All vent joints must be LIQUID and PRESSURE TIGHT.

Page 3 - VICTORY 3

VICTORY 11at test pressures equal to or less than 1/2 PSIG.D. All gas piping used should be inspected thoroughly forcleanliness before makeup. A sedim

Page 4

12VICTORYB. PUMP LOCATION-Locating low-head pump(s) onreturn to boiler is acceptable for smaller boiler sizes inresidences of one or two stories. The

Page 5 - VICTORY 5

VICTORY 138. Turn on all electric power to the appliance.9. Set thermostat to desired setting.10. If the appliance will not operate, follow the instru

Page 6 - 6 VICTORY

14VICTORY2. Safety Shutdown Checkouta. For proper operation the pilot should engulf thethermocouple, powerpile generator or flame sen-sor as shown bel

Page 7 - VICTORY 7

VICTORY 15burners as described on page 13.*To clean burners run a clean flue brush up the tubeuntil all foreign matter is removed.IV. SAFETY CHECK FOR

Page 8

16VICTORYAPPENDIX ARemoval Of Existing Boiler From Common Vent System"At the time of removal of an existing boiler, the followingsteps shall be f

Page 9

VICTORY 17Sequence of Operations Wiring DiagramsCAUTION: Label all wires prior to disconnection when servicing controls.Wiring errors can cause improp

Page 10

18VICTORYPUMP OR VALVE ZONING OF WATER BOILERSCOMBINATION CONTROLS WITH T TV Z TERMINALS*Pump Zoning system using R845 Relay.One R-845A nee

Page 11 - VICTORY 1

VICTORY 19BURNERS FAIL TO OPERATECAUSE1. Safety pilot out, or flame too low.2. Gas supply valve shut off.3. Electric switch open.4. Blown or defective

Page 12 - Figure 11

2 VICTORYDimensions (inches)Figure 1. Left End ViewFigure 2. Front ViewFigure 3. Right End ViewNOTE: Height Dimension increases to 30-3/16" and d

Page 13

20 VICTORYPIPING A HEATING - COOLING SYSTEM TO A WATERBOILER AND CHILLERFigure below illustrates a method of piping a heating-coolingsystem to a wate

Page 14

VICTORY 3INSTALLATION REQUIREMENTSThe installation must conform to the requirements of theauthority having jurisdiction or, in the absence of suchrequ

Page 15

4 VICTORYReference Table No. *ApplianceConnector Requirements*(ANSI Z223.1)Victory Boilers Type “B” See table 11-1 for minimum and maximum of vent 11-

Page 16

VICTORY 5HORIZONTAL PRESSURE VENTINGAll VICTORY models are certified for horizontal pressureventing with the following restrictions:1. Vent MaterialA.

Page 17

Model/Vent SizeV-90, V-120, V-150 and V-180 boilers may be vented into achimney (see “Chimney and type “B” venting” paragraph onpage 4) or into a type

Page 18

VICTORY 7Figure 6b. Venting with “B” vent or metal-lined chimney for V-90, V-120, V-150 and V-180 onlyMinimum vent connectors diameter is 5 inches. It

Page 19

8 VICTORYFigure 7. Horizontal Venting (3 IN.): All Victory ModelsAll items shown below are REQUIRED. All vent joints must be LIQUID and PRESSURE TIGHT

Page 20

VICTORY9Figure 8. Horizontal Venting (3 IN.): All Victory ModelsAll items shown below are REQUIRED. All vent joints must be LIQUID and PRESSURE TIGHT

Modèles reliés V-180

Commentaires sur ces manuels

Pas de commentaire

Slant_fin V-33 Manuel d'utilisateur

Naviguer en ligne ou télécharger Manuel d'utilisateur pour Chaudière à eau Slant_fin V-33. Slant/Fin V-33 User Manual Manuel d'utilisatio

Résumé du contenu

Modèles reliés V-180

Commentaires sur ces manuels

Produits connexes et manuels pour Chaudière à eau Slant_fin V-33